World Library  
Flag as Inappropriate
Email this Article

Bhopal disaster

Bhopal disaster
Bhopal memorial for those killed and disabled by the 1984 toxic gas release
Date 2 December 1984 (1984-12-02)–3 December 1984 (1984-12-03)
Location Bhopal, Madhya Pradesh
Also known as Bhopal gas tragedy
Cause Gas leak from Union Carbide India Limited storage tank
Deaths At least 3,787; over 16,000 claimed
Non-fatal injuries At least 558,125

The Bhopal disaster, also referred to as the Bhopal gas tragedy, was a gas leak incident in India, considered the world's worst industrial disaster.[1]

It occurred on the night of 2–3 December 1984 at the Union Carbide India Limited (UCIL) pesticide plant in Bhopal, Madhya Pradesh. Over 500,000 people were exposed to methyl isocyanate (MIC) gas and other chemicals. The toxic substance made its way into and around the shanty towns located near the plant.[2]

Estimates vary on the death toll. The official immediate death toll was 2,259. The government of Madhya Pradesh confirmed a total of 3,787 deaths related to the gas release.[3] A government affidavit in 2006 stated that the leak caused 558,125 injuries, including 38,478 temporary partial injuries and approximately 3,900 severely and permanently disabling injuries.[4] Others estimate that 8,000 died within two weeks, and another 8,000 or more have since died from gas-related diseases.[5]

The cause of the disaster remains under debate. The Indian government and local activists argue that slack management and deferred maintenance created a situation where routine pipe maintenance caused a backflow of water into a MIC tank triggering the disaster. Union Carbide Corporation (UCC) contends water entered the tank through an act of sabotage.

The owner of the factory, UCIL, was majority owned by UCC, with Indian Government-controlled banks and the Indian public holding a 49.1 percent stake. In 1989, UCC paid $470m ($907m in 2014 dollars) to settle litigation stemming from the disaster. In 1994, UCC sold its stake in UCIL to Eveready Industries India Limited (EIIL), which subsequently merged with McLeod Russel (India) Ltd. Eveready ended clean-up on the site in 1998, when it terminated its 99-year lease and turned over control of the site to the state government of Madhya Pradesh. Dow Chemical Company purchased UCC in 2001, seventeen years after the disaster.

Civil and criminal cases were filed in the District Court of Bhopal, India, involving UCC and Warren Anderson, UCC CEO at the time of the disaster.[6][7] In June 2010, seven ex-employees, including the former UCIL chairman, were convicted in Bhopal of causing death by negligence and sentenced to two years imprisonment and a fine of about $2,000 each, the maximum punishment allowed by Indian law. An eighth former employee was also convicted, but died before the judgement was passed.[1] Anderson also died at a nursing home in Vero Beach, Florida on September 29, 2014.


  • The pre-event phase 1
    • Earlier leaks 1.1
  • The leakage and its subsequent effects 2
    • The release 2.1
      • The gas cloud 2.1.1
    • Acute effects 2.2
      • Immediate aftermath 2.2.1
    • Subsequent legal action 2.3
    • Post-settlement activity 2.4
  • Long-term effects 3
    • Long-term health effects 3.1
    • Health care 3.2
    • Environmental rehabilitation 3.3
    • Occupational and habitation rehabilitation 3.4
    • Economic rehabilitation 3.5
    • Other impacts 3.6
  • Causes of the disaster: overview 4
    • Causes of the disaster: The "corporate negligence" argument 4.1
    • Causes of the disaster: the "disgruntled employee sabotage" case 4.2
    • The argument for sabotage 4.3
  • Additional Union Carbide actions 5
    • Charges against UCC and UCIL employees 5.1
  • Ongoing contamination 6
  • Film 7
  • Activism 8
    • Local activism 8.1
    • International activism 8.2
    • Activist organisations 8.3
    • Settlement fund hoax 8.4
    • Monitoring of Bhopal activists 8.5
  • See also 9
  • Citations 10
  • References 11
    • Union Carbide Corporation 11.1
  • External links 12

The pre-event phase

The UCIL factory was built in 1969 to produce the pesticide Sevin (UCC's brand name for carbaryl) using methyl isocyanate (MIC) as an intermediate.[5] A MIC production plant was added in 1979.[8][9][10] After the Bhopal plant was built, other manufacturers, including Bayer, produced carbaryl without MIC, though at a greater manufacturing cost. However, Bayer also used the UCC process at the chemical plant once owned by UCC at Institute, West Virginia, in the United States.[11][12]

The chemical process employed in the Bhopal plant had methylamine reacting with phosgene to form MIC, which was then reacted with 1-naphthol to form the final product, carbaryl. This "route" differed from the MIC-free routes used elsewhere, in which the same raw materials were combined in a different manufacturing order, with phosgene first reacting with naphthol to form a chloroformate ester, which was then reacted with methylamine. In the early 1980s, the demand for pesticides had fallen, but production continued, leading to build-up of stores of unused MIC.[5][11]

Earlier leaks

In 1976, two trade unions complained of pollution within the plant.[5][13] In 1981, a worker was splashed with phosgene. In a panic, he removed his mask, inhaling a large amount of phosgene gas which resulted in his death 72 hours later.[5][13] Local Indian authorities had warned the company of the problem as early as 1979, but constructive actions were not undertaken by UCIC at that time.[5][11] In January 1982, a phosgene leak exposed 24 workers, all of whom were admitted to a hospital. None of the workers had been ordered to wear protective masks. One month later, in February 1982, a MIC leak affected 18 workers. In August 1982, a chemical engineer came into contact with liquid MIC, resulting in burns over 30 percent of his body. Later that same year, in October 1982, there was another MIC leak. In attempting to stop the leak, the MIC supervisor suffered severe chemical burns and two other workers were severely exposed to the gases. During 1983 and 1984, there were leaks of MIC, chlorine, monomethylamine, phosgene, and carbon tetrachloride, sometimes in combination.[5][13]

The leakage and its subsequent effects

The release

Tank 610 in 2010. During decontamination of the plant, tank 610 was removed from its foundation and left aside
Methylamine (1) reacts with phosgene (2) producing methyl isocyanate (3) which reacts with 1-naphthol (4) to yield carbaryl (5)

In November 1984, most of the safety systems were not functioning and many valves and lines were in poor condition. In addition, several vent gas scrubbers had been out of service as well as the steam boiler, intended to clean the pipes. Another issue was that Tank 610 contained 42 tons of MIC, more than safety rules allowed for.[5] During the night of 2–3 December 1984, water entered a side pipe that was missing its slip-blind plate and entered Tank E610, which contained 42 tons of MIC. A runaway reaction started, which was accelerated by contaminants, high temperatures and other factors. The reaction was sped up by the presence of iron from corroding non-stainless steel pipelines.[5] The resulting exothermic reaction increased the temperature inside the tank to over 200 °C (392 °F) and raised the pressure. This forced the emergency venting of pressure from the MIC holding tank, releasing a large volume of toxic gases. About 30 metric tons of MIC escaped from the tank into the atmosphere in 45 to 60 minutes.[2]

The gas cloud

The gases were blown in a southeasterly direction over Bhopal.[5][14]

As of 2008, UCC had not released information about the possible composition of the cloud. Apart from MIC, the gas cloud may have contained phosgene, hydrogen cyanide, carbon monoxide, hydrogen chloride, oxides of nitrogen, monomethyl amine and carbon dioxide, either produced in the storage tank or in the atmosphere. As the gas cloud was composed mainly of materials denser than the surrounding air, it stayed close to the ground and spread outwards through the surrounding community.[5] The chemical reactions may have produced a liquid or solid aerosol.[15] Laboratory investigations by CSIR and UCC scientists failed to demonstrate the presence of hydrogen cyanide.[16][17]

Acute effects

Reversible reaction of glutathione (top) with methyl isocyanate (MIC, middle) allows the MIC to be transported into the body

The initial effects of exposure were coughing, severe eye irritation and a feeling of suffocation, burning in the respiratory tract, blepharospasm, breathlessness, stomach pains and vomiting. People awakened by these symptoms fled away from the plant. Those who ran inhaled more than those who had a vehicle to ride. Owing to their height, children and other people of shorter stature inhaled higher concentrations.

Thousands of people had died by the following morning.

Primary causes of deaths were choking, reflexogenic circulatory collapse and pulmonary oedema. Findings during autopsies revealed changes not only in the lungs but also cerebral oedema, tubular necrosis of the kidneys, fatty degeneration of the liver and necrotising enteritis.[18] The stillbirth rate increased by up to 300% and neonatal mortality rate by around 200%.[5]

Immediate aftermath

In the immediate aftermath, the plant was closed to outsiders (including UCC) by the Indian government, which subsequently failed to make data public, contributing to the confusion. The initial investigation was conducted entirely by the Council of Scientific and Industrial Research (CSIR) and the Central Bureau of Investigation. The UCC chairman and CEO Warren Anderson, together with a technical team, immediately traveled to India. Upon arrival, however, Anderson was placed under house arrest and urged by the Indian government to leave the country within 24 hours. Union Carbide organized a team of international medical experts, as well as supplies and equipment, to work with the local Bhopal medical community, and the UCC technical team began assessing the cause of the gas leak.

The health care system immediately became overloaded. In the severely affected areas, nearly 70 percent were underqualified doctors. Medical staff were unprepared for the thousands of casualties. Doctors and hospitals were not aware of proper treatment methods for MIC gas inhalation.[5]:6

There were mass funerals and cremations. Within a few days, trees in the vicinity became barren and bloated animal carcasses had to be disposed of. 170,000 people were treated at hospitals and temporary dispensaries; 2,000 buffalo, goats, and other animals were collected and buried. Supplies, including food, became scarce owing to suppliers' safety fears. Fishing was prohibited causing further supply shortages.[5]

Lacking any safe alternative, on 16 December, tanks 611 and 619 were emptied of the remaining MIC by reactivating the plant and continuing the manufacture of pesticide. Despite safety precautions such as having water carrying helicopters continually overflying the plant, this led to a second mass evacuation from Bhopal. The Government of India passed the "Bhopal Gas Leak Disaster Act" that gave the government rights to represent all victims, whether or not in India. Complaints of lack of information or misinformation were widespread. An Indian government spokesman said, "Carbide is more interested in getting information from us than in helping our relief work".[5]

Formal statements were issued that air, water, vegetation and foodstuffs were safe, but warned not to consume fish. The number of children exposed to the gases was at least 200,000.[5] Within weeks, the State Government established a number of hospitals, clinics and mobile units in the gas-affected area to treat the victims.

UCC established a relief fund and offered interim relief. The Indian government turned down the offer.

Subsequent legal action

Number of women pictured in black and white colour, sitting and protesting against Anderson and the company.
Victims of Bhopal disaster march in September 2006 demanding the extradition of American Warren Anderson from the United States.

Legal proceedings involving UCC, the United States and Indian governments, local Bhopal authorities, and the disaster victims started immediately after the catastrophe. The Indian Government passed the Bhopal Gas Leak Act in March 1985, allowing the Government of India to act as the legal representative for victims of the disaster,[19] leading to the beginning of legal proceedings. In March 1986 UCC proposed a settlement figure, endorsed by plaintiffs' U.S. attorneys, of $350 million that would, according to the company, "generate a fund for Bhopal victims of between $500–600 million over 20 years". In May, litigation was transferred from the United States to Indian courts by U.S. District Court Judge. Following an appeal of this decision, the U.S. Court of Appeals affirmed the transfer, judging, in January 1987, that UCIL was a "separate entity, owned, managed and operated exclusively by Indian citizens in India".[19]

The Government of India refused the offer from Union Carbide and claimed US$3.3 billion.[5] The Indian Supreme Court told both sides to come to an agreement and "start with a clean slate" in November 1988.[19] Eventually, in an out-of-court settlement reached in February 1989, Union Carbide agreed to pay US$470 million for damages caused in the Bhopal disaster.[5] The amount was immediately paid.

Throughout 1990, the Indian Supreme Court heard appeals against the settlement. In October 1991, the Supreme Court upheld the original $470 million, dismissing any other outstanding petitions that challenged the original decision. The Court ordered the Indian government "to purchase, out of settlement fund, a group medical insurance policy to cover 100,000 persons who may later develop symptoms" and cover any shortfall in the settlement fund. It also requested UCC and its subsidiary UCIL "voluntarily" fund a hospital in Bhopal, at an estimated $17 million, to specifically treat victims of the Bhopal disaster. The company agreed to this.[19]

Post-settlement activity

In 1991, the local Bhopal authorities charged Anderson, who had retired in 1986, with manslaughter, a crime that carries a maximum penalty of 10 years in prison. He was declared a fugitive from justice by the Chief Judicial Magistrate of Bhopal on 1 February 1992 for failing to appear at the court hearings in a culpable homicide case in which he was named the chief defendant. Orders were passed to the Government of India to press for an extradition from the United States. The U.S. Supreme Court refused to hear an appeal of the decision of the lower federal courts in October 1993, meaning that victims of the Bhopal disaster could not seek damages in a U.S. court.[19]

In 2004, the Indian Supreme Court ordered the Indian government to release any remaining settlement funds to victims. And in September 2006, the Welfare Commission for Bhopal Gas Victims announced that all original compensation claims and revised petitions had been "cleared".[19] The [19]

In June 2010, seven former employees of UCIL, all Indian nationals and many in their 70s, were convicted of causing death by negligence: Keshub Mahindra, former non-executive chairman of Union Carbide India Limited; V. P. Gokhale, managing director; Kishore Kamdar, vice-president; J. Mukund, works manager; S. P. Chowdhury, production manager; K. V. Shetty, plant superintendent; and S. I. Qureshi, production assistant. They were each sentenced to two years imprisonment and fined Rs.100,000 (US$2,124). All were released on bail shortly after the verdict.

US Federal class action litigation, Sahu v. Union Carbide and Warren Anderson, had been filed in 1999 under the U.S. Alien Torts Claims Act (ATCA), which provides for civil remedies for "crimes against humanity."[20] It sought damages for personal injury, medical monitoring and injunctive relief in the form of clean-up of the drinking water supplies for residential areas near the Bhopal plant. The lawsuit was dismissed in 2012 and subsequent appeal denied.[21] Anderson died in 2014.

Long-term effects

Long-term health effects

Some data about the health effects are still not available. The Indian Council of Medical Research (ICMR) was forbidden to publish health effect data until 1994.[5]

A total of 36 wards were marked by the authorities as being "gas affected," affecting a population of 520,000. Of these, 200,000 were below 15 years of age, and 3,000 were pregnant women. The official immediate death toll was 2,259, and in 1991, 3,928 deaths had been officially certified. Ingrid Eckerman estimated 8,000 died within two weeks.[5][22]

The government of Madhya Pradesh confirmed a total of 3,787 deaths related to the gas release.[3]

Later, the affected area was expanded to include 700,000 citizens. A government affidavit in 2006 stated the leak caused 558,125 injuries including 38,478 temporary partial injuries and approximately 3,900 severely and permanently disabling injuries.[4]

A cohort of 80,021 exposed people was registered, along with a control group, a cohort of 15,931 people from areas not exposed to MIC. Nearly every year since 1986, they have answered the same questionnaire. It shows overmortality and overmorbidity in the exposed group. However, bias and confounding factors cannot be excluded from the study. Because of migration and other factors, 75% of the cohort is lost, as the ones who moved out are not followed.[5][23]

A number of clinical studies are performed. The quality varies, but the different reports support each other.[5] Studied and reported long term health effects are:

  • Eyes: Chronic conjunctivitis, scars on cornea, corneal opacities, early cataracts
  • Respiratory tracts: Obstructive and/or restrictive disease, pulmonary fibrosis, aggravation of TB and chronic bronchitis
  • Neurological system: Impairment of memory, finer motor skills, numbness etc.
  • Psychological problems: Post traumatic stress disorder (PTSD)
  • Children’s health: Peri- and neonatal death rates increased. Failure to grow, intellectual impairment, etc.

Missing or insufficient fields for research are female reproduction, chromosomal aberrations, cancer, immune deficiency, neurological sequelae, post traumatic stress disorder (PTSD) and children born after the disaster. Late cases that might never be highlighted are respiratory insufficiency, cardiac insufficiency (cor pulmonale), cancer and tuberculosis.

A 2014 report in Mother Jones quotes a "spokesperson for the Bhopal Medical Appeal, which runs free health clinics for survivors" as saying "An estimated 120,000 to 150,000 survivors still struggle with serious medical conditions including nerve damage, growth problems, gynecological disorders, respiratory issues, birth defects, and elevated rates of cancer and tuberculosis."[24]

Health care

The Government of India had focused primarily on increasing the hospital-based services for gas victims thus hospitals had been built after the disaster. When UCC wanted to sell its shares in UCIL, it was directed by the Supreme Court to finance a 500-bed hospital for the medical care of the survivors. Thus, Bhopal Memorial Hospital and Research Centre (BMHRC) was inaugurated in 1998 and was obliged to give free care for survivors for eight years. BMHRC was a 350-bedded super speciality hospital where heart surgery and hemodialysis were done. However, there was a dearth of gynaecology, obstetrics and paediatrics. Eight mini-units (outreach health centres) were started and free health care for gas victims were to be offered till 2006.[5] The management had also faced problems with strikes, and the quality of the health care being disputed.[25][26] Sambhavna Trust is a charitable trust, registered in 1995, that gives modern as well as ayurvedic treatments to gas victims, free of charge.[5][27]

Environmental rehabilitation

When the factory was closed in 1986, pipes, drums and tanks were sold. The MIC and the Sevin plants are still there, as are storages of different residues. Isolation material is falling down and spreading.[5] The area around the plant was used as a dumping area for hazardous chemicals. In 1982 chromium, copper, nickel, lead, hexachloroethane, hexachlorobutadiene, and the pesticide HCH.[5]

In order to provide safe drinking water to the population around the UCIL factory, Government of Madhya Pradesh presented a scheme for improvement of water supply.[29] In December 2008, the Madhya Pradesh High Court decided that the toxic waste should be incinerated at Ankleshwar in Gujarat, which was met by protests from activists all over India.[30] On 8 June 2012, the Centre for incineration of toxic Bhopal waste agreed to pay 250 million (US$3.8 million) to dispose of UCIL chemical plants waste in Germany.[31] On 9 August 2012, Supreme court directed the Union and Madhya Pradesh Governments to, take immediate steps for disposal of toxic waste lying around and inside the factory within six months.[32]

A U.S. court rejected the lawsuit blaming UCC for causing soil and water pollution around the site of the plant and ruled that responsibility for remedial measures or related claims rested with the State Government and not with UCC.[33] In 2005, the state government invited various Indian architects to enter their "concept for development of a memorial complex for Bhopal gas tragedy victims at the site of Union Carbide". In 2011, a conference was held on the site, with participants from European universities which was aimed for the same.[34][35]

Occupational and habitation rehabilitation

33 of the 50 planned work-sheds for gas victims started. All except one was closed down by 1992. 1986, the MP government invested in the Special Industrial Area Bhopal. 152 of the planned 200 work sheds were built and in 2000, 16 were partially functioning. It was estimated that 50,000 persons need alternative jobs, and that less than 100 gas victims had found regular employment under the government's scheme. The government also planned 2,486 flats in two- and four-story buildings in what is called the "widow's colony" outside Bhopal. The water did not reach the upper floors and it was not possible to keep cattle which were their primary occupation. Infrastructure like buses, schools, etc. were missing for at least a decade.[5]

Economic rehabilitation

Immediate relieves were decided two days after the tragedy. Relief measures commenced in 1985 when food was distributed for a short period along with ration cards.[5] Madhya Pradesh government's finance department allocated 874 million (US$13 million) for victim relief in July 1985.[36][37] Widow pension of 200 (US$3.00)/per month (later 750 (US$11)) were provided. The government also decided to pay 1500 (US$23) to families with monthly income 500 (US$7.50) or less. As a result of the interim relief, more children were able to attend school, more money was spent on treatment and food, and housing also eventually improved. From 1990 interim relief of 200 (US$3.00) was paid to everyone in the family who was born before the disaster.[5]

The final compensation, including interim relief for personal injury was for the majority 25,000 (US$380). For death claim, the average sum paid out was 62,000 (US$940). Each claimant were to be categorised by a doctor. In court, the claimants were expected to prove "beyond reasonable doubt" that death or injury in each case was attributable to exposure. In 1992, 44 percent of the claimants still had to be medically examined.[5]

By the end of October 2003, according to the Bhopal Gas Tragedy Relief and Rehabilitation Department, compensation had been awarded to 554,895 people for injuries received and 15,310 survivors of those killed. The average amount to families of the dead was $2,200.[38]

In 2007, 1,029,517 cases were registered and decided. Number of awarded cases were 574,304 and number of rejected cases 455,213. Total compensation awarded was 15465 million (US$230 million).[29] On 24 June 2010, the Union Cabinet of the Government of India approved a 12650 million (US$190 million) aid package which would be funded by Indian taxpayers through the government.[39]

Other impacts

In 1985, Henry Waxman, a California Democrat, called for a U.S. government inquiry into the Bhopal disaster, which resulted in U.S. legislation regarding the accidental release of toxic chemicals in the United States.[40]

Causes of the disaster: overview

There are two main lines of argument involving the disaster. The "Corporate Negligence" point of view argues that the disaster was caused by a potent combination of under-maintained and decaying facilities, a weak attitude towards safety, and an undertrained workforce, culminating in worker actions that inadvertently enabled water to penetrate the MIC tanks in the absence of properly working safeguards.[5][22]

The "Worker Sabotage" point of view argues that it was not physically possible for the water to enter the tank without concerted human effort, and that extensive testimony and engineering analysis leads to a conclusion that water entered the tank when a rogue individual employee hooked a water hose directly to an empty valve on the side of the tank. This point of view further argues that the Indian government took extensive actions to hide this possibility in order to attach blame to UCC.[41]

Theories differ as to how the water entered the tank. At the time, workers were cleaning out a clogged pipe with water about 400 feet from the tank. They claimed that they were not told to isolate the tank with a pipe slip-blind plate. The operators assumed that owing to bad maintenance and leaking valves, it was possible for the water to leak into the tank.[5][42]

However, this water entry route could not be reproduced despite strenuous efforts by motivated parties.[43] UCC claims that a "disgruntled worker" deliberately connecting a hose to a pressure gauge connection was the real cause.[5][41]

Early the next morning, a UCIL manager asked the instrument engineer to replace the gauge. UCIL's investigation team found no evidence of the necessary connection; however, the investigation was totally controlled by the government, denying UCC investigators access to the tank or interviews with the operators.[41][44]

Causes of the disaster: The "corporate negligence" argument

This point of view argues that management (and to some extent, local government) did not uphold spending on safety and allowed for a dangerous working environment to develop and continuously worsen. Factors cited include the filling of the MIC tanks beyond recommended levels, poor maintenance after the plant ceased MIC production at the end of 1984, allowing several safety systems to be inoperable due to poor maintenance, and switching off safety systems to save money— including the MIC tank refrigeration system which could have mitigated the disaster severity, and non-existent catastrophe management plans.[5][22] Other factors identified by government inquiries included undersized safety devices and the dependence on manual operations.[5] Specific plant management deficiencies that were identified include the lack of skilled operators, reduction of safety management, insufficient maintenance, and inadequate emergency action plans.[5][13]


Underinvestment is cited as contributing to an environment. Attempts to reduce expenses affected the factory's employees and their conditions. Kurzman argues that "cuts ... meant less stringent quality control and thus looser safety rules. A pipe leaked? Don't replace it, employees said they were told ... MIC workers needed more training? They could do with less. Promotions were halted, seriously affecting employee morale and driving some of the most skilled ... elsewhere".[45] Workers were forced to use English manuals, even though only a few had a grasp of the language.[42][46]

Subsequent research highlights a gradual deterioration of safety practices in regard to the MIC, which had become less relevant to plant operations. By 1984, only six of the original twelve operators were still working with MIC and the number of supervisory personnel had also been halved. No maintenance supervisor was placed on the night shift and instrument readings were taken every two hours, rather than the previous and required one-hour readings.[42][45] Workers made complaints about the cuts through their union but were ignored. One employee was fired after going on a 15-day hunger strike. 70% of the plant's employees were fined before the disaster for refusing to deviate from the proper safety regulations under pressure from the management.[42][45]

In addition, some observers, such as those writing in the Trade Environmental Database (TED) Case Studies as part of the Mandala Project from American University, have pointed to "serious communication problems and management gaps between Union Carbide and its Indian operation", characterised by "the parent companies [sic] hands-off approach to its overseas operation" and "cross-cultural barriers".[47]

Adequacy of equipment and safety regulations

The factory was not well equipped to handle the gas created by the sudden addition of water to the MIC tank. The MIC tank alarms had not been working for four years and there was only one manual back-up system, compared to a four-stage system used in the United States.[5][22][42][48] The flare tower and several vent gas scrubbers had been out of service for five months before the disaster. Only one gas scrubber was operating: it could not treat such a large amount of MIC with sodium hydroxide (caustic soda), which would have brought the concentration down to a safe level.[48] The flare tower could only handle a quarter of the gas that leaked in 1984, and moreover it was out of order at the time of the incident.[5][22][42][49] To reduce energy costs, the refrigeration system was idle. The MIC was kept at 20 degrees Celsius, not the 4.5 degrees advised by the manual.[5][22][42][48] Even the steam boiler, intended to clean the pipes, was non-operational for unknown reasons.[5][22][42][48] Slip-blind plates that would have prevented water from pipes being cleaned from leaking into the MIC tanks, had the valves been faulty, were not installed and their installation had been omitted from the cleaning checklist.[5][22][42] As MIC is water-soluble, deluge guns were in place to contain escaping gases from the stack. However, the water pressure was too weak for the guns to spray high enough to reach the gas which would have reduced the concentration of escaping gas significantly.[5][22][42][48] In addition to it, carbon steel valves were used at the factory, even though they were known to corrode when exposed to acid.[11]

According to the operators, the MIC tank pressure gauge had been malfunctioning for roughly a week. Other tanks were used, rather than repairing the gauge. The build-up in temperature and pressure is believed to have affected the magnitude of the gas release.[5][22][42][48] UCC admitted in their own investigation report that most of the safety systems were not functioning on the night of 3 December 1984.[50] The design of the MIC plant, following government guidelines, was "Indianized" by UCIL engineers to maximise the use of indigenous materials and products. Mumbai-based Humphreys and Glasgow Consultants Pvt. Ltd., were the main consultants, Larsen & Toubro fabricated the MIC storage tanks, and Taylor of India Ltd. provided the instrumentation.[16] In 1998, during civil action suits in India, it emerged that the plant was not prepared for problems. No action plans had been established to cope with incidents of this magnitude. This included not informing local authorities of the quantities or dangers of chemicals used and manufactured at Bhopal.[5][11][22][42]

Safety audits

Safety audits were done every year in the US and European UCC plants, but only every two years in other parts of the world.[5][51] Before a "Business Confidential" safety audit by UCC in May 1982, the senior officials of the corporation were well aware of "a total of 61 hazards, 30 of them major and 11 minor in the dangerous phosgene/methyl isocyanate units" in Bhopal.[5][52] In the audit 1982, it was indicated that worker performance was below standards.[5][44] Ten major concerns were listed.[5] UCIL prepared an action plan, but UCC never sent a follow-up team to Bhopal. Many of the items in the 1982 report were temporarily fixed, but by 1984, conditions had again deteriorated.[44] In September 1984, an internal UCC report on the Virginia plant in the USA revealed a number of defects and malfunctions. It warned that "a runaway reaction could occur in the MIC unit storage tanks, and that the planned response would not be timely or effective enough to prevent catastrophic failure of the tanks". This report was never forwarded to the Bhopal plant, although the main design was the same.[53]

Causes of the disaster: the "disgruntled employee sabotage" case

Now owned by Dow Chemical Company, Union Carbide maintains a website dedicated to the tragedy and claims that the incident was the result of sabotage, stating that sufficient safety systems were in place and operative to prevent the intrusion of water.[54]

The impossibility of the "negligence" argument

According to the "Corporate Negligence" argument, workers had been cleaning out pipes with water nearby. This water was diverted due to a combination of improper maintenance, leaking and clogging, and eventually ended up in the MIC storage tank. Indian scientists also suggested that additional water might have been introduced as a "back-flow" from a defectively designed vent-gas scrubber. However, none of these theoretical routes of entry were ever successfully demonstrated during tests by the Central Bureau of Investigators (CBI) and UCIL engineers.[42][44][51][55]

An analysis by Arthur D. Little argues that the Negligence argument was impossible for several tangible reasons:[41]

  1. The pipes being used by the nearby workers were only 1/2 inch in diameter and were physically incapable of producing enough hydraulic pressure to raise water the more than 10 feet that would have been necessary to enable the water to "backflow" into the MIC tank.
  2. A key intermediate valve would have had to be open for the Negligence argument to apply. However, this valve was "tagged" closed, meaning that it had been inspected and found to be closed. While it is possible for open valves to clog over time, the only way a closed valve allows penetration is if there is leakage, and 1985 tests carried out by the government of India found this valve to be non-leaking.
  3. In order for water to have reached the MIC tank from the pipe-cleaning area, it would have had to flow through a significant network of pipes ranging from 6 to 8 inches in diameter, before rising ten feet and flowing into the MIC tank. Had this occurred, most of the water that was in those pipes at the time the tank had its critical reaction would have remained in those pipes, as there was no drain for them. However, investigation by the Indian government in 1985 revealed that the pipes were bone dry.

The argument for sabotage

The Arthur D. Little report concludes that it is likely that a single employee secretly and deliberately introduced a large amount of water into the MIC tank by removing a meter and connecting a water hose directly to the tank through the metering port.[41]

UCC claims the plant staff falsified numerous records to distance themselves from the incident and absolve themselves of blame, and that the Indian Government impeded its investigation and declined to prosecute the employee responsible, presumably because that would weaken its allegations of negligence by Union Carbide.[56]

The evidence in favor of this point of view includes:

  1. A key witness (the "tea boy") testified that when he entered the control room at 12:15am, prior to the disaster, the "atmosphere was tense and quiet".
  2. Another key witness (the "instrument supervisor") testified that when he arrived at the scene immediately following the incident, he noticed that the local pressure indicator on the critical Tank 610 was missing, and that he had found a hose lying next to the empty manhead created by the missing pressure indicator, and that the hose had had water running out of it.
  3. This testimony was corroborated by other witnesses.
  4. Graphological analysis revealed major attempts to alter logfiles and destroy log evidence.
  5. Other logfiles show that the control team had attempted to purge 1 ton of material out of Tank 610 immediately prior to the disaster. An attempt was then made to cover up this transfer via log alteration. Water is heavier than MIC, and the transfer line is attached to the bottom of the tank. The Arthur D. Little report concludes from this that the transfer was an effort to transfer water out of Tank 610 that had been discovered there.
  6. A third key witness (the "off-duty employee of another unit") stated that "he had been told by a close friend of one of the MIC operators that water had entered through a tube that had been connected to the tank." This had been discovered by the other MIC operators (so the story was recounted) who then tried to open and close valves to prevent the release.
  7. A fourth key witness (the "operator from a different unit") stated that after the release, two MIC operators had told him that water had entered the tank through a pressure gauge.

The Little report argues that this evidence demonstrates that the following chronology actually took place:

  • At 10:20pm, the tank was at normal pressure, indicating the absence of water.
  • At 10:45pm, a shift change took change, during which time the MIC storage area "would be completely deserted".
  • During this period, a "disgruntled operator entered the storage area and hooked up one of the readily available rubber water hoses to Tank 610, with the intention of contaminating and spoiling the tank's contents."
  • Water began to flow, beginning the chemical reaction that caused the disaster.
  • After midnight, control room operators saw the pressure rising and realized there was a problem with Tank 610. They discovered the water connection, and decided to transfer one ton of the contents out to try and remove the water.
  • The disaster then occurred, a major release of poisonous gas.
  • The cover-up activities discovered during the investigation then took place.

Additional Union Carbide actions

The corporation denied the claim that the valves on the tank were malfunctioning, and claimed that the documented evidence gathered after the incident showed that the valve close to the plant's water-washing operation was closed and was leak-tight. Furthermore, process safety systems had prevented water from entering the tank by accident. Carbide states that the safety concerns identified in 1982 were all allayed before 1984 and had nothing to do with the incident.[57]

The company admitted that the safety systems in place would not have been able to prevent a chemical reaction of that magnitude from causing a leak. According to Carbide, "in designing the plant's safety systems, a chemical reaction of this magnitude was not factored in" because "the tank's gas storage system was designed to automatically prevent such a large amount of water from being inadvertently introduced into the system" and "process safety systems—in place and operational—would have prevented water from entering the tank by accident". Instead, they claim that "employee sabotage—not faulty design or operation—was the cause of the tragedy".[57]

Tactical response

The company stresses the immediate action taken after the disaster and its continued commitment to helping the victims. On 4 December, the day following the leak, Union Carbide sent material aid and several international medical experts to assist the medical facilities in Bhopal.[57]

Financial response

The primary financial restitution paid by UCC was negotiated in 1989, when the Indian Supreme Court approved a settlement of US$470 million (1055 crore (equivalent to 58 billion or US$870 million in 2016)). This amount was immediately paid by UCC to the Indian government. The company states that the restitution paid "was $120 million more than plaintiffs' lawyers had told U.S. courts was fair" and that the Indian Supreme Court stated in its opinion that "compensation levels under the settlement were far greater than would normally be payable under Indian law."[58]

In the immediate aftermath of the disaster, Union Carbide states on its website that it put $2 million into the Indian prime minister's immediate disaster relief fund on 11 December 1984.[57] The corporation established the Employees' Bhopal Relief Fund in February 1985, which raised more than $5 million for immediate relief.[19] According to Union Carbide, in August 1987, they made an additional $4.6 million in humanitarian interim relief available.[19]

Union Carbide stated that it also undertook several steps to provide continuing aid to the victims of the Bhopal disaster. The sale of its 50.9 percent interest in UCIL in April 1992 and establishment of a charitable trust to contribute to the building of a local hospital. The sale was finalised in November 1994. The hospital was begun in October 1995 and was opened in 2001. The company provided a fund with around $90 million from sale of its UCIL stock. In 1991, the trust had amounted approximately $100 million. The hospital catered for the treatment of heart, lung and eye problems.[54] UCC also provided a $2.2 million grant to Arizona State University to establish a vocational-technical center in Bhopal, which was opened, but was later closed by the state government.[58] They also donated $5 million to the Indian Red Cross after the disaster.[58] They also developed a Responsible Care system with other members of the chemical industry as a response to the Bhopal crisis, which was designed to help prevent such an event in the future.[19]

Charges against UCC and UCIL employees

UCC chairman and CEO Warren Anderson was arrested and released on bail by the Madhya Pradesh Police in Bhopal on 7 December 1984. Anderson was taken to UCC's house after which he was released six hours later on $2,100 bail and flown out on a government plane. These actions were allegedly taken under the direction of then chief secretary of the state, who was possibly instructed from chief minister's office, who himself flew out of Bhopal immediately.[59][60][61] Later in 1987, the Indian government summoned Anderson, eight other executives and two company affiliates with homicide charges to appear in Indian court.[62] In response, Union Carbide said the company is not under Indian jurisdiction.[62]

From 2014, Dow is a named respondent in a number of ongoing cases arising from Union Carbide’s business in Bhopal.[63]

Ongoing contamination

A view of MIC plant surrounded by few metal pipes
Deteriorating section of the MIC plant, decades after the gas leak.

Chemicals abandoned at the plant continue to leak and pollute the groundwater.[38][64][65][66] Whether the chemicals pose a health hazard is disputed.[67] Contamination at the site and surrounding area was not caused by the gas leakage. The area around the plant was used as a dumping ground for hazardous chemicals and by 1982 water wells in the vicinity of the UCIL factory had to be abandoned.[5] UCC states that "after the incident, UCIL began clean-up work at the site under the direction of Indian central and state government authorities", which was continued after 1994 by the successor to UCIL. The successor, Eveready Industries India, Limited (EIIL), ended cleanup on the site in 1998, when it terminated its 99-year lease and turned over control of the site to the state government of Madhya Pradesh.[19][54]

UCC's laboratory tests in 1989 revealed that soil and water samples collected from near the factory were toxic to fish. Twenty-one areas inside the plant were reported to be highly polluted. In 1991 the municipal authorities declared that water from over 100 wells was hazardous for health if used for drinking.[5] In 1994 it was reported that 21% of the factory premises were seriously contaminated with chemicals.[28][68][69] Beginning in 1999, studies made by [73] Chemicals that have been linked to various forms of cancer were also discovered, as well as trichloroethylene, known to impair fetal development, at 50 times above safety limits specified by the U.S. Environmental Protection Agency (EPA).[72] In 2002, an inquiry by Fact-Finding Mission on Bhopal found a number of toxins, including mercury, lead, 1,3,5 trichlorobenzene, dichloromethane and chloroform, in nursing women's breast milk.

A 2004 carcinogenic toxin.[77] In October 2011, the Institute of Environmental Management and Assessment published an article and video by two British environmental scientists, showing the current state of the plant, landfill and solar evaporation ponds and calling for renewed international efforts to provide the necessary skills to clean up the site and contaminated groundwater.[78]


To coincide with the 30th anniversary of the disaster, historical-drama Bhopal: A Prayer for Rain, starring Martin Sheen as Union Carbide CEO Warren Anderson, Kal Penn, and Mischa Barton was released. The film has earned global praise and LA Times critic Martin Tsai said the film was "ambitious and shattering" and that "Although the real-life events took place three decades ago, the cautionary tale could not be more relevant."[79]


Since 1984, individual activists have played a role in the aftermath of the tragedy. The best-known is Satinath Sarangi (Sathyu), a metallurgic engineer who arrived at Bhopal the day after the leakage. He founded several activist groups, as well as Sambhavna Trust, the clinic for gas affected patients, where he is the manager.[5] Other activists include Rashida Bee and Champa Devi Shukla, who received the Goldman Prize in 2004, Abdul Jabbar and Rachna Dhingra.[80][81]

Local activism

Soon after the accident, representatives from different activist groups arrived. The activists worked on organising the gas victims, which led to violent repression from the police and the government.[5]

Numerous actions have been performed: demonstrations, sit-ins, hunger strikes, marches combined with pamphlets, books, and articles. Every anniversary, actions are performed. Often these include marches around Old Bhopal, ending with burning an effigy of Warren Anderson.

International activism

Cooperation with international NGOs including Pesticide Action Network UK and Greenpeace started soon after the tragedy. One of the earliest reports is the Trade Union report from ILO 1985.[44]

In 1992, a session of the Permanent Peoples' Tribunal on Industrial Hazards and Human Rights took place in Bhopal, and in 1996,the "Charter on Industrial Hazards and Human Rights" was adopted.

In 1994, the International Medical Commission on Bhopal (IMCB) met in Bhopal. Their work contributed to long term health effects being officially recognised.

Important international actions have been the tour to Europe and United States in 2003,[82] the marches to Delhi in 2006 and 2008, all including hunger strikes, and the Bhopal Europe Bus Tour in 2009.

Activist organisations

At least 14 different NGOs were immediately engaged.[5] The first disaster reports were published by activist organisations, Eklavya and the Delhi Science Forum.

Around ten local organisations, engaged on long term, have been identified. Two of the most active organisations are the women's organisations—Bhopal Gas Peedit Mahila-Stationery Karmachari Sangh and Bhopal Gas Peedit Mahila Udyog Sangthan.[5]

More than 15 national organisations have been engaged along with a number of international organisations.[5]

Some of the most important organisations are:

Settlement fund hoax

On 3 December 2004, the twentieth anniversary of the disaster, a man falsely claiming to be a Dow representative named Jude Finisterra was interviewed on BBC World News. He claimed that the company had agreed to clean up the site and compensate those harmed in the incident, by liquidating Union Carbide for US$12 billion.[83][84] Dow quickly issued a statement saying that they had no employee by that name—that he was an impostor, not affiliated with Dow, and that his claims were a hoax. The BBC later broadcast a correction and an apology.[85]

Jude Finisterra was actually Andy Bichlbaum, a member of the activist prankster group The Yes Men. In 2002, The Yes Men issued a fake press release explaining why Dow refused to take responsibility for the disaster and started up a website, at "", designed to look like the real Dow website, but containing hoax information.[86]

Monitoring of Bhopal activists

A Stratfor was leaked by WikiLeaks on 27 February 2012.[87] It revealed that Dow Chemical had engaged Stratfor to spy on the public and personal lives of activists involved in the Bhopal disaster, including the Yes Men. E-mails to Dow representatives from hired security analysts list the YouTube videos liked, Twitter and Facebook posts made and the public appearances of these activists.[88] Stratfor released a statement condemning the revelation by Wikileaks while neither confirming nor denying the accuracy of the reports, and would only state that it had acted within the bounds of the law. Dow Chemical also refrained to comment on the matter.[89]

Ingrid Eckerman, a member of the International Medical Commission on Bhopal, has been denied a visa to visit India.[90]

See also


  1. ^ a b
  2. ^ a b
  3. ^ a b
  4. ^ a b
  5. ^ a b c d e f g h i j k l m n o p q r s t u v w x y z aa ab ac ad ae af ag ah ai aj ak al am an ao ap aq ar as at au av aw ax ay az ba bb bc
  6. ^
  7. ^
  8. ^ F-41443A-7/76
  9. ^
  10. ^
  11. ^ a b c d e Kovel (2002).
  12. ^
  13. ^ a b c d
  14. ^
  15. ^
  16. ^ a b D'Silva, The Black Box of Bhopal (2006).
  17. ^
  18. ^ Sriramachari (2004).
  19. ^ a b c d e f g h i j k
  20. ^
  21. ^ http://www.earthrights.orgs/default/files/documents/District-Court-June-2012-dismissal-of-Sahu-I.pdf
  22. ^ a b c d e f g h i j k
  23. ^
  24. ^
  25. ^
  26. ^
  27. ^
  28. ^ a b
  29. ^ a b
  30. ^
  31. ^
  32. ^
  33. ^
  34. ^
  35. ^
  36. ^
  37. ^
  38. ^ a b
  39. ^
  40. ^
  41. ^ a b c d e
  42. ^ a b c d e f g h i j k l m Chouhan et al. (2004).
  43. ^
  44. ^ a b c d e The Trade Union Report on Bhopal, Geneva, Switzerland: ICFTU-ICEF, 1985
  45. ^ a b c Kurzman (1987).
  46. ^ Cassels (1983).
  47. ^ Mandala Project (1996), Trade Environmental Database (TED) Case Study 233. Volume 5, Number 1, January, 1996
  48. ^ a b c d e f Lepowski
  49. ^ Weir (1987).
  50. ^
  51. ^ a b
  52. ^
  53. ^
  54. ^ a b c
  55. ^
  56. ^
  57. ^ a b c d
  58. ^ a b c
  59. ^
  60. ^
  61. ^
  62. ^ a b
  63. ^
  64. ^
  65. ^
  66. ^
  67. ^
  68. ^ a b Labunska et al. (2003).
  69. ^ a b Down to Earth (2003).
  70. ^ Stringer et al. (2002).
  71. ^ Srishti (2002).
  72. ^ a b
  73. ^ Greenpeace Research Laboratories, Department of Biological Sciences, University of Exeter, Exeter UK
  74. ^
  75. ^
  76. ^
  77. ^
  78. ^
  79. ^
  80. ^
  81. ^
  82. ^
  83. ^
  84. ^
  85. ^
  86. ^
  87. ^
  88. ^
  89. ^
  90. ^


  • Union Carbide India Limited, Agricultural Products Division: Bhopal (1978)
  • Cassels, J. (1993). The Uncertain Promise of Law: Lessons From Bhopal. University of Toronto Press.
  • Main author Chouhan was an operator at the plant. Contains many technical details.
  • Review Written by a retired former employee of UCC who was a member of the investigation committee. Includes several original documents including correspondence between UCIL and the Ministries of the Government of India.
  • Essay for MPH. A short overview, 57 pages, 82 references.
  • Preview Google books All known facts 1960s – 2003, systematised and analysed. 283 pages, over 200 references.
  • ISBN 1-891843-32-X USA, 81-85569-70-3 India. Reprinting and annotating landmark writing from across the years.
  • In Down to Earth
  • London: The Institution of Chemical Engineers Conference on Preventing Major Chemical Accidents
  • [In Swedish]
  • Kurzman, D. (1987). A Killing Wind: Inside Union Carbide and the Bhopal Catastrophe. New York: McGraw-Hill.
  • Greenpeace Research Laboratories, Department of Biological Sciences, University of Exeter, Exeter UK
  • Lepowski, W. "Ten Years Later: Bhopal". Chemical and Engineering News, 19 December 1994.
  • Union Carbide Corporation, New York (1976)

Union Carbide Corporation

  • Methyl Isocyanate. Union Carbide F-41443A – 7/76. Union Carbide Corporation, New York (1976)
  • Carbon monoxide, Phosgene and Methyl isocyanate. Unit Safety Procedures Manual. Union Carbide India Limited, Agricultural Products Division: Bhopal (1978)
  • Operating Manual Part II. Methyl Isocyanate Unit. Union Carbide India Limited, Agricultural Products Division (1979).
  • Bhopal Methyl Isocyanate Incident. Investigation Team Report. Union Carbide Corporation, Danbury, CT (1985).
  • Presence of Toxic Ingredients in Soil/Water Samples Inside Plant Premises. Union Carbide Corporation, US (1989).

External links

  • International Campaign for Justice in Bhopal
  • Bhopal Medical Appeal
  • Bhopal Gas Tragedy Relief & Rehabilitation Department at the Government of Madhya Pradesh
  • Bhopal Information Center, Union Carbide
  • India Environmental Portal Updated news on Bhopal Gas Disaster
  • Bhopal:Anatomy of a Crisis Paul Shrivastava, Paul Chapman Publishing, 1987, ISBN 1-85396-192-2
This article was sourced from Creative Commons Attribution-ShareAlike License; additional terms may apply. World Heritage Encyclopedia content is assembled from numerous content providers, Open Access Publishing, and in compliance with The Fair Access to Science and Technology Research Act (FASTR), Wikimedia Foundation, Inc., Public Library of Science, The Encyclopedia of Life, Open Book Publishers (OBP), PubMed, U.S. National Library of Medicine, National Center for Biotechnology Information, U.S. National Library of Medicine, National Institutes of Health (NIH), U.S. Department of Health & Human Services, and, which sources content from all federal, state, local, tribal, and territorial government publication portals (.gov, .mil, .edu). Funding for and content contributors is made possible from the U.S. Congress, E-Government Act of 2002.
Crowd sourced content that is contributed to World Heritage Encyclopedia is peer reviewed and edited by our editorial staff to ensure quality scholarly research articles.
By using this site, you agree to the Terms of Use and Privacy Policy. World Heritage Encyclopedia™ is a registered trademark of the World Public Library Association, a non-profit organization.

Copyright © World Library Foundation. All rights reserved. eBooks from Project Gutenberg are sponsored by the World Library Foundation,
a 501c(4) Member's Support Non-Profit Organization, and is NOT affiliated with any governmental agency or department.