World Library  
Flag as Inappropriate
Email this Article

American Eagle Flight 4184

American Eagle Flight 4184
An American Eagle ATR 72–212 similar to N401AM at Santo Domingo airport, Dominican Republic
Accident summary
Date Monday, 31 October 1994
Summary Atmospheric icing, Loss of control
Site Lincoln Township, Newton County, near Roselawn, Indiana, U.S.
Passengers 64
Crew 4
Fatalities 68 (all)
Survivors 0
Aircraft type ATR 72–212
Operator Simmons Airlines doing business as American Eagle
Registration N401AM
Flight origin Indianapolis International Airport
Destination Chicago O'Hare International Airport

American Eagle Flight 4184[1] was an American Eagle ATR 72 that crashed after flying into unknown icing conditions on Monday, October 31, 1994. Control was lost and all aboard were killed.


  • History 1
  • Probable cause 2
  • Aftermath 3
  • Memorials 4
  • Dramatization 5
  • See also 6
  • References 7
  • External links 8


The aircraft, N401AM, was built by the Franco-Italian aircraft manufacturer ATR, and was operated by Simmons Airlines on behalf of American Eagle. American Eagle was the banner carrier regional airline branding program of AMR Corporation's regional system, prior to the formation of the fully certificated carrier named American Eagle Airlines. The flight was en route from Indianapolis International Airport, Indiana to O'Hare International Airport, Chicago, Illinois. Bad weather in Chicago caused delays, prompting air traffic control to hold Flight 4184 over the nearby LUCIT intersection at 10,000 ft (3,000 m).

The captain of Flight 4184 was Orlando Aguiar, 29. He was an experienced pilot with almost 8,000 hours of flight time. Colleagues described Aguiar's flying skills in positive terms and commented on the relaxed cockpit atmosphere that he promoted. The first officer of Flight 4184 was Jeffrey Gagliano, 30. He, too, was considered to be a competent pilot by colleagues and he had accumulated more than 5,000 flight hours. The two flight attendants were Amanda Holberg, 23, and Sandi Modaff, 27.

While holding, the plane encountered freezing rain – a dangerous icing condition where supercooled droplets rapidly cause intense ice buildup. Soon after, they were cleared to descend to 8,000 ft (2,400 m). After this descent the pilots were ordered to make another hold. During the descent, a warning sound indicating an overspeed warning due to the extended flaps was heard in the cockpit. After the pilot took action by retracting the flaps, a strange noise was heard on the cockpit voice recorder, followed by an uncommanded roll excursion which disengaged the autopilot. Flight recorder data showed that the aircraft subsequently went through at least one full roll with Aguiar and Gagliano able to successfully regain control of the rapidly descending aircraft. However, another roll occurred shortly thereafter. Fewer than thirty seconds later, contact was lost as the plane crashed into a soybean field near Roselawn, Indiana (coordinates: +41° 5' 39.84", −87° 19' 19.92"), killing all 64 passengers and 4 crew on board. The disintegration of the plane indicated an extreme velocity, and data recovered from the flight data recorder verified that the plane was traveling 375 knots (695 km/h) indicated airspeed at impact.[2] There was no explosion or post-impact fire, as the high speed of the impact caused the fuel to disperse before it could ignite. The bodies of all on board were fragmented by the impact forces, therefore the crash site was declared a biohazard.

Flight 4184 was the first loss of an ATR 72 aircraft and remains the highest death toll of any aviation accident involving an ATR 72 anywhere in the world. Robert A. Clifford, a Chicago airplane accident attorney, represented 16 of the victims. As the trial was ready to begin, the defendants agreed to a record $110 million settlement and an apology from both the manufacturer and the airline in open court.[3]

Probable cause

Following the crash near Roselawn, longstanding problems with the ATR aircraft operating in some icing conditions were revealed by Stephen Fredrick (a whistleblower later fired by the airline).[4]

The National Transportation Safety Board (NTSB) issued its usual statement of "probable cause" near the end of the report. However, that statement was considerably longer than is the norm for most other NTSB accident reports. The statement clearly blamed ATR (the manufacturer of that aircraft), the French DGAC (the French equivalent of the American FAA), and the FAA itself, as contributing to that accident, because they all failed in their duty to ensure the highest possible level of safety to the traveling public. The unabridged NTSB "probable cause" statement:

3.2 Probable Cause
The National Transportation Safety Board determines that the probable causes of this accident were the loss of control, attributed to a sudden and unexpected aileron hinge moment reversal that occurred after a ridge of ice accreted beyond the deice boots because: 1) ATR failed to completely disclose to operators, and incorporate in the ATR 72 airplane flight manual, flightcrew operating manual and flightcrew training programs, adequate information concerning previously known effects of freezing precipitation on the stability and control characteristics, autopilot and related operational procedures when the ATR 72 was operated in such conditions; 2) the French Directorate General for Civil Aviation's (DGAC's) inadequate oversight of the ATR 42 and 72, and its failure to take the necessary corrective action to ensure continued airworthiness in icing conditions; and 3) the DGAC's failure to provide the FAA with timely airworthiness information developed from previous ATR incidents and accidents in icing conditions, as specified under the Bilateral Airworthiness Agreement and Annex 8 of the International Civil Aviation Organization.
Contributing to the accident were: 1) the Federal Aviation Administration's (FAA's) failure to ensure that aircraft icing certification requirements, operational requirements for flight into icing conditions, and FAA published aircraft icing information adequately accounted for the hazards that can result from flight in freezing rain and other icing conditions not specified in 14 Code of Federal Regulations (CFR) Part 25, Appendix C; and 2) the FAA's inadequate oversight of the ATR 42 and 72 to ensure continued airworthiness in icing conditions.[5]


In the years following this accident, AMR Corporation stopped using its American Eagle ATRs out of its northern hubs and moved them to its southern and Caribbean hubs at Dallas-Fort Worth International Airport; Miami, Florida and San Juan, Puerto Rico to alleviate potential icing problems in the future. Other U.S. former ATR operators, particularly the SkyWest, Inc. subsidiary and Delta Connection operator Atlantic Southeast Airlines, operated ATR 72 aircraft in areas where icing conditions were not common.

In April, 1996 the American FAA issued 18 Airworthiness Directives (ADs), in an apparent attempt to prevent further icing accidents in ATR aircraft. They included significant revisions of pilot operating procedures in icing conditions (higher minimum speeds, non-use of the autopilot, different upset recovery procedures) as well as physical changes to the coverage area of the de-icing boots on the airfoils.

While the ATR 42 and ATR 72 aircraft are now compliant with all icing condition requirements imposed by those 18 ADs, the de-icing boots still only reach back to 12.5% of the chord. Prior to the accident, they had extended only to 5% and 7%, respectively. They still fail to deal with the findings of the Boscombe Down tests, conducted by British regulators, which demonstrated that ice could form as far back on the wing as 23% of the chord, and on the tail at 30% of chord. Both percentages remain well beyond the limits of the extended deicing boots, installed in compliance with those FAA ADs.

Those tests limited the size of the droplets to 40 micrometres, near the maximum limit of the FAA design certification rules for Transport Category aircraft (Part 25, Appendix C), still in effect at that time of the Roselawn crash. Extensive airborne testing, following that accident, revealed it is possible for airliners to encounter water droplets exceeding 200 micrometers in average diameter.[6]

It is likely that the lack of further ATR icing accidents is attributable to the changes in pilot operating procedures, as well as the moving of those aircraft to operating areas where severe icing is not a problem, rather than to the modest extension of the de-icer boots to 12.5% of the chord.[7]


There are three designated memorials for Flight 4184. The first is a roadside memorial[8] at the crash location just outside of Roselawn, Indiana. The second is located at Calumet Park Cemetery,[8][9] in Merrillville, Indiana, where 18 caskets of unidentified remains were interred. The third is located at the Lincoln Township Fire Department[8] in Thayer, Indiana, the station from which the first emergency responders came to the crash site.


This crash was featured on an episode of the Discovery Channel program The New Detectives. In the episode, entitled "Witness To Terror," the narrator gives an incorrect figure of 72 victims being killed on the flight.[10] The crash was also featured in the theatrical production Charlie Victor Romeo.

The crash would later be featured in Season 7 of Discovery Channel's Mayday / National Geographic's Air Crash Investigation in the episode Frozen In Flight.

The crash was also briefly mentioned in an episode of Modern Marvels (Sub Zero) on The History Channel.

See also


  1. ^ "Frozen in Flight". Mayday.
  2. ^ ASN Aircraft accident description Aérospatiale/Aeritalia ATR 72–212 N401AM – Roselawn, IN
  3. ^
  4. ^ Fredrick, Stephen A. (1996). Unheeded warning: the inside story of American Eagle flight 4184. McGraw-Hill. pp. 326 pages.  
  5. ^ "NTSB Report: American Eagle Flight 4184". Pg. 210
  6. ^ Steward, Danette; Boser, Robert J. (ed.) (September 2002). "Letter to the Editor – Unheeded Warning". Retrieved June 2014. 
  7. ^ Unheeded Warning: The Inside Story of American Eagle Flight 4184
  8. ^ a b c
  9. ^
  10. ^ The Internet Movie Database – The New Detectives: Case Studies In Forensic Science (Season 2, Episode 11 – Witness To Terror) (1998)

External links

  • Accident description at the Aviation Safety Network
  • NTSB AAR-96/01 – NTSB Aircraft Accident Report PDF (3.58 MiB), 340 pages)
  • NTSB AAR-96/02 – Comments of Bureau Enquête-Accidents PDF (4.42 MiB), 341 pages)
  • PlaneCrashInfo.Com entry on Flight 4184
  • Tv.Com – New Detectives: Witness to Terror (Details Flight 4184 investigation)
  • Site for Families and Friends of 4184
This article was sourced from Creative Commons Attribution-ShareAlike License; additional terms may apply. World Heritage Encyclopedia content is assembled from numerous content providers, Open Access Publishing, and in compliance with The Fair Access to Science and Technology Research Act (FASTR), Wikimedia Foundation, Inc., Public Library of Science, The Encyclopedia of Life, Open Book Publishers (OBP), PubMed, U.S. National Library of Medicine, National Center for Biotechnology Information, U.S. National Library of Medicine, National Institutes of Health (NIH), U.S. Department of Health & Human Services, and, which sources content from all federal, state, local, tribal, and territorial government publication portals (.gov, .mil, .edu). Funding for and content contributors is made possible from the U.S. Congress, E-Government Act of 2002.
Crowd sourced content that is contributed to World Heritage Encyclopedia is peer reviewed and edited by our editorial staff to ensure quality scholarly research articles.
By using this site, you agree to the Terms of Use and Privacy Policy. World Heritage Encyclopedia™ is a registered trademark of the World Public Library Association, a non-profit organization.

Copyright © World Library Foundation. All rights reserved. eBooks from Project Gutenberg are sponsored by the World Library Foundation,
a 501c(4) Member's Support Non-Profit Organization, and is NOT affiliated with any governmental agency or department.